Tag Archives: building inspection

Quality Assurance Observations

A Roofing Contractor Messes Up, William Leys Waterproofing Consultants LLC Helps Client Get It Fixed

A Low Slope Roof Installation Went Awry When The Contractor Deviated From The Manufacturers Installation Instructions

William Leys Waterproofing Consultants LLC Steps in to Assist The Building Owner Get the Work Corrected

A recent consult job that we had for a client who just had a new low slope roof installed on their building showed the reason that building owners should consider hiring a quality assurance inspector to ensure that the roof is installed right the first time and doesn’t have to be done over.

A client reached out to us who just had a new roof installed on their building. They had concerns about the workmanship and requested our assistance to inspect the job and document the problems with the installation. A low slope roof with a single ply TPO membrane had multiple issues with the installation.

Improper Termination of Membrane at Skylight
Improper Termination of Membrane at Door Threshold
Improper Weld is Open
Numerous Low Spots From Improper Slope on Roof
Improper Termination of Membrane at Roof To Wall
Improper Termination of Membrane Into Roof Drain
Vent Boot Not Caulked or Clamped

As you can see from the photo gallery we found numerous problems with the installation. We wrote a detailed report for the client who then was able to go to the contractor and ask them to make corrections to their work. The city building department refused to sign off on the permit for the roof because of the poor workmanship and the client threatened to complain to the Contractors State License Board if the contractor did not step up and replace and repair his poor work.

All in all a happy ending for the client who had paid quite a bit of money for this roof. We would encourage anybody who is replacing a roof that’s going to cost over six figures to add a little bit more money into their budget and pay for quality assurance observations during the installation which had this client done so would have avoided this issue.

Reach out today for a quote on your quality assurance observations on your next project.

leyswaterproofingconsultants@gmail.com
805-801-2380
Quality Assurance Observations

William Leys Waterproofing Consultants LLC To Perform Quality Assurance Inspections for an HOA in the San Francisco Bay Area

We will be performing quality assurance inspections on this project in the East Bay.

We’re excited to announce that we were awarded the contract to perform quality assurance inspections for a large HOA reconstruction project in the East Bay area of San Francisco. The 100+ units in the HOA are leaking at the decks and resulted in damage to the exterior walls.

We will be performing periodic inspections of the weather resistant barriers (WRB’s) the installation of sliding doors and the waterproofing of the decks to ensure that they are being installed in accordance with the plans and specifications. This helps the Association ensure its money is being spent well on quality work and the materials are installed correctly that will last for their expected life spend and perform as intended.

Observing installation of new WRBs integrated into the existing WRBs.
A sliding door with the screw coming through the threshold.
Building paper installed before weep screed…? It shouldn’t be.

If your HOA is about to undertake a major renovation project, talk to us about how we can help protect your interests by providing quality assurance inspections that will help spot problems before they get away. We report directly to the association and provide a daily report for every visit along with extensive photo documentation. Catching a problem before it’s covered over will save a lot of heartache and finger pointing later on. We find that contractors like having quality assurance inspectors on site because they know that we are there to help the project through to a successful completion.

Reach out today for a conversation on why your association should have a quality assurance inspector on your six-figure + project.

SB 326 Balcony Inspections

Using Humorous Memes To Get Our Message Out- Protect Your HOA from Unethical SB326 Inspectors Who Own Waterproofing/Contracting Companies

Is humor the best way to market our SB326 inspection services? Viral memes seem to resonate with people these days so it’s worth a shot.

If you need a SB326 inspection you need to vet your inspector thoroughly. Are they independent and free of conflicts of interest? Any inspection company that owns a waterproofing or contracting company is not free of conflicts of interest.

We’ve seen multiple clients coming to us with SB326 reports in hand that were written by contractors, signed off on by an engineer who didn’t actually inspect the EEEs and the report is written to favor the contractor who now uses that report to extort HOAs reserve funds.

At William Leys Waterproofing Consultants LLC we guarantee in writing that we have no conflicts of interest. We don’t own a waterproofing or contracting company, we hire a structural engineer who writes the report and we write a supplemental waterproofing report that is appended to the engineers report.

Call today, time is running out for getting your inspection done before the deadline. 805-801-2380 ask for Bill.

SB 326 Balcony Inspections, Uncategorized

A Competitors Guarantee Gives Away Their Game

We compete against Dr Balcony around central and southern California. They are members of multiple CAI Chapters. Despte their low price offer, I know of at least 2x we won a job against them even though my company submitted a bid that was more than theirs.


Why? When I was able to give a presentation to a board of directors and explain how we operated, that we had a licensed structural engineer performing the inspections, that I did a supplemental waterproofing report that was attended to the engineers stamped and sealed report, that we inspected 100% of all the EEEs to ensure that nothing was overlooked, we were awarded the job. They saw my years of experience as a waterproofing contractor, that an engineer was personally on site doing the inspection, that our no conflicts of interest guarantee that we don’t bid on repairs, that we get competitive bids without obstructing the free market, that the 20% discount is a fraudulent attempt to subvert the market, where competitive bidding and a companies experience matter.

I have it on good authority from a client who had this company on site & when they saw who was inspecting the deck complained to their HOA, lo and behold an architect appeared and inspected their deck at that time. They did not know if the architect continued to inspect other decks or just theirs.

I am making inquiries to the Architectural Board & the Board of Engineers as to whether the engineer or architect has to actually be on site & perform the inspections or if they can allow an individual without any engineering or architectural qualifications to perform the inspection basically write the report & then they will put a cover letter on that says the report is accurate.

This offer of taking 20% off the lowest bid that the association received  is just a bad sales tactic because they want to do the repairs, & that 20% off will be easily added back into the cost of the repairs because who is keeping them honest once they get the work?

Let’s math. Let’s say my company bid your inspection, with a guaranteed structural engineer, with a no conflicts of interest guarantee in writing as well, at 20k. For sake of a comparison, let’s say Dr Balcony had bid 21k.

So they daty hey, we will beat their price by 20% so their new price is now 16k. So what they just admitted to is that the value of their work is actually only sixteen thousand instead of the twenty one thousand they originally quoted you.

The question that comes to my mind is are they saying that they could have bid lower but they bid higher with hopes of overcharging you?  Now that they know they overbid, suddenly they want to make it up to you? You weren’t born yesterday… And you realize that Dr Balcony has inherent conflicts of interest, and is attempting to limit your choices of contractors, you should realize that some companies are actively trying to scam you.

If a company says they can do it all in house without needing to go to outside contractors to get three bids then they are limiting your ability to receive the best bid for repairs, they are stifling market competition, and your HOA is likely to be greatly overcharged.

Let us explain to your HOA why an independent firm without conflicts of interest is your best choice when it comes to balcony inspections.

We will explain what non emergency repairs and emergency repairs are, and why some companies push non emergency repairs over to emergency status, to pressure you into signing with them immediately before you get a chance to look around and shop your options.

Reach out to me, Bill Leys directly at 805-801-2380 for a consultation on how we can help you.

Deck Inspections

Why Having a Consultant On Your Side Saves You Heartache…

A client we are working with on a balcony inspection proposal walked us through their underground garage to get to the other side of the building so we could count the decks. As we walked through the garage I mentioned that that were a lot of leak areas and I saw that there was some crumbling concrete as well.

They said oh we are getting the leaks fixed, we have two bids and we are going to hire X company to do the waterproofing on the podium deck above. I said that’s good because you have some problems here… What are they doing? It was then they showed me the two scopes of work that the contractors had proposed to do.

This scope of work mentions nothing about using any particular brand or specific material. It is poorly written and leaves out many important steps that this job requires.
Poorly written as well, this scope of work is ambiguous and like the first scope, has no mention of any brand names or warranty.

We initiated a conversation with the client and discussed these proposals and corresponding scopes of work. The client believed that the work they were ready to award to a contractor was going to fix their problems. Several issues they had were a failing coating on the podium deck, leaks into the building and severe degradation of the structural concrete deck.

Under the podium deck is significant deterioration.
If you see these symptoms in your concrete, you have 99 problems but a waterproof deck ain’t one.
Hidden behind a pan on the ceiling to catch water, hidden structural damage.
Up above on the deck, failing coatings are dangerous to bare feet and they leak into the deck below.
Failing coating at the pool deck coping.
A very clogged up downspout is causing water to back up and causing leaking into the building.

We gave the Association a proposal to consult and perform non destructive percussion testing of their concrete deck and the coating on top. The engineer we partner with and I inspected the deck and as seen above, found some serious damage to the concrete and rebar inside. We found that nearly all of the coating on the top of the deck was delaminated and failing. We found that there was stress on the walls that the pool was set into.

This all added up to the conclusion that simply recoating the deck was not the answer. This Association needs structural concrete repair work done, removal of the coating on the deck, all new flashings around the perimeter, shot-blasting to provide a profiled surface for new coatings to bond to the existing, sloping to drains, cleaning out the drain pipes and a new non slip waterproof coating applied after all prep work was completed.

The job will cost them more than 181k. However, they will receive in return a lot more for their money. They have a consultant on their side that will get responsible contractors to bid on repairs, with quality assurance monitoring to watch over the contractors work and a written warranty from a quality manufacturer.

The Association now knows that they were going to lose 181k of their money and get little in return for it. The two bids were from supposed quality contractors, but we won’t be asking these two companies to bid this project. They should know better than to throw these bids out to their client, but IMO they don’t care about the client and that’s why we won’t ever use them to bid our jobs that we are consulting on.

Reach out today to discuss how we can help your association with your Waterproofing project. Call me, Bill Leys at 805-801-2380 direct or use the contact us box to send us an email. We can get you on the path to completing a successful project that will bring value to your property.

SB 326 Balcony Inspections, SB 721 Inspections

Grover Beach Deck Destroyed By High Winds Reveals Why It Failed -Extensive Dry-rot & Improper Connections

A high wind event that hit Grover Beach in San Luis Obispo county on Wednesday shows us why inspections of decks are so important.

Improper connections of wood panels with glazing in them to the framing & Extensive Dry-rot at posts.

.

The apartment building on Grand Ave has a walkway on the second floor, and at some point someone added large panes of acrylic sheets or glass in wood frames to help block the near constant wind that comes through.

The high winds exposed the significant dry-rot that was present in the framing and posts, along with exposing the weak connections. Unfortunately due to the structural damage several residents are not able to access their homes and are living in a motel temporarily.

Because of the damage residents could not return to their homes.

Landlords and HOAs can avoid the liability and potential injuries to residents and guests by having their EEEs inspected by the experts at William Leys Waterproofing Consultants LLC.

We can do your SB721 and SB326 balcony inspections for you and get you into compliance. Do not expose yourself to unnecessary liability by failing to get inspected.

Reach out today for a free EEE evaluation and proposal.

Quality Assurance Observations

William Leys Waterproofing Consultants LLC Investigates Leaks on New Addition in Avila Beach

We are pleased to announce that we have been retained to investigate leaks on a new addition on an Avila Beach residence by the owners of the property.

The owners of the property had hired a local contractor, who with a team of subcontractors built a dining room with a deck above to expand the living space and take advantage of the views that they have. The contractor completed the project shortly before last winter’s rains started up and the owners quickly realized that there were leak problems in several areas of the new construction.

We have performed visual inspections as well as rudimentary water testing that has found several areas of concern that will need to be further investigated via destructive testing.

Water testing a window in the search for leaks

If you’re building is leaking reach out to us today for assistance in investigating the cause and devising a solution to repair the problem. The longer you wait the worse the damage can become with water intrusion issues into structural elements.

We’re ready to reach, call us at 805-801-2380.

SB 326 Balcony Inspections

Santa Barbara County HOA Selects William Leys Waterproofing Consultants LLC For SB 326 Deck Inspections

We’re pleased to have been selected by an HOA in Santa Barbara County to perform their SB 326 balcony inspections.

The 32 unit association has walkways, stairs and exclusive use decks that need to be inspected, and after a competitive bidding process, selected us as the best qualified firm to perform the inspection.

William Leys Waterproofing Consultants LLC guarantees that we have no conflicts of interest in owning any waterproofing or construction firm and that an award winning structural engineer inspects the EEEs and as waterproofing experts, our inspection of flashings, waterproofing and related items gives Associations confidence knowing that they have retained a well qualified firm.

We invite you to experience the expertise that we offer as deck inspectors. Call us or email us using the contact us box today to get started.

Deck Inspections, SB 326 Balcony Inspections

Railing Failure Illustrates the Importance of Doing Balcony Inspections

A 9 year old child is lucky to be alive and only suffered some relatively minor injuries when the railing on a deck he was playing on gave way and he fell from the second story deck to the ground.

Our screen grabs from a TV news channel shows just how bad a shape the railing that still remains on the deck is in.

Stiles on the right side of the deck are obviously in poor condition. The whole front part of the railing is gone, indicating widespread dry-rot and likely improper fastening of the railing to the posts.
The remains of the railing lay below the upper deck.

I’ve seen similar railings like this in the past where a carpenter uses a nail in the top of the railing and one on the bottom to attach the stile. This method is not a very good method to achieve a 200 pound resistance to someone leaning against it, and especially for small children who are probably leaning on the stile’s themselves. These cheap wood stiles will often rot out in a few years from being exposed to water.

On one inspection I did at a property for sale, I kicked the wood stiles with a bit of minor force and the stiles failed. The seller was furious that I “damaged” his property, but I pointed out that if his grandchild leaned on that railing he likely would have fallen 15 feet to a concrete sidewalk below. My answer was I probably saved someone’s life, so fix it properly.

A better method of protecting occupants is to use pre built railings that are made of metal welded together in the factory.

Falls through railings are unfortunately a common occurrence, and many result in death or severe injuries. Years ago a Board member of a condo I managed fell through a dry-rotted railing while on vacation, after a few days he passed away from grievous injuries.

This is another example of why we inspect folks.

When it comes to life safety, don’t fool around folks, the reason we inspect is to prevent accidents.

If you are buying a property with decks and railings, have it inspected by an expert like ourselves before closing.

If you are an HOA get your decks inspected by the experts at William Leys Waterproofing Consultants LLC. We guarantee that we have no conflicts of interest and that we only work for the associations best interests.

SB 326 Balcony Inspections

An EEE Evaluation May Have Helped Stop a Stair Collapse

On Monday we were in Pasadena looking at an association for the purpose of counting how many decks stairs walkways they have so we could bid to perform a SB 326 inspection job. The property is in an older established area that has Magnesite decking in the stairs and decks.

One stairway caught my eye with the long large crack in the Magnesite rubbing down the stair stringer. This critical piece of framing behind the Magnesite has, in my opinion, been infiltrated with water, has swollen and caused the Magnesite to crack and is likely dry-rotted as well, creating a life safety concern should it fail with people in the stairs.

We alerted the Board of Directors and their HOA manager to have the stairs shored up until repairs can be made. We would be remiss if we did not.

An EEE evaluation is not an inspection of the decks and stairs, but it is important to do in person to see the actual site conditions… And who knows, maybe we’ll catch a potential life safety issue at your association while we’re at it.

This is why we inspect, to protect life/safety and preserve your Associations property. Feel free to reach out to us for your free proposal for an SB 326 Inspection.